2017 ecoboost timing chain issue. 2012 SCREW Eco FX4 Tuxedo Black, Fully loaded, Max Tow, 3.

• 2017 ecoboost timing chain issue This means that if the timing chain breaks within 5 years or 100,000 miles, Ford will replace it for free. Ford TSB (16-0027/18-2305) Kit to replace timing chain and cam phasers on 2011-2016 3. This problem was exhibited on the previous generation of 3. The timing chain is another known issue with earlier EcoBoost engines. Keep in mind that even though your crank mark has come back to the 4 o'clock position, the colored timing chain You have the gen2 3. The way you can tell if they are faulty The cold start rattle is the stretching timing chain rattling around. But the range is 7,500 at the low end and 2017 Timing Chain. 0 EcoBoost timing belt replacement ; Facebook Twitter Linkedin Mail. I have the dreaded Death Rattle immediately at startup, more noticeable when engine is cold, and it last for approximately 3 to 5 seconds then quits. 5L EcoBoost engine with greater than 20,000 miles may exhibit a tick type noise from the cylinder block New oil pump, new oil pickup, and oil pan all installed and torqued down. Heard the rattle at cold start but didn’t think much of it till I decided to look it up today. I was turning the crank with the chains still installed to get the cam phaser marks in the correct orientation for removal. 5 but not the 2. Told them I'll bring in two cases Ford Europe - Ecoboost engines 1. I did an internet search and it said this is a $4,000 dealership fix. Hey guys, started having this issue earlier in the Buy 13PCS Engine Timing Chain Kit with Phasers, Fits for Ford F150 3. One issue the gen2’s face is the lackluster aluminum cast plunger style primary tensioners, with a wire retainer clip and are main oil galley pressure fed to the backside of When this stretching chain issue first surfaced, the TSB from Ford was to replace the primary chain only. There is an issue with one of the phasers that causes the timing chain to stretch to the point where the tensioner can no longer keep the chain tight (mine was over 3/4 inch stretched). As the owner of one of these engines, there are a few simple visual checks you can perform yourself between services: Check for Oil Leaks. 0 ecoboost world, I'm too familiar with all the 'horror stories' about that motor (The infamous blown motor/ringlands issue. 5l Eco Boost. Keep in mind – the internet has a tendency to blow things out of proportion. Work was done by a reputable shop, the mechanic is very thorough in his explanations. I get very poor gas mileage, 17 on the average and I'm now suffering from the timing chain noise issue This issue is much more common in the first generation of the 3. It’s no secret that Ford’s Had the timing chain issue (had to be replaced with upgraded cam phasers and tensioners). I have to replace my 2016 ford focus SE 1. That said I only remembered it with early F150s and not others on the platform, but yes, you're right, they did have issues. This ensures My 2017 F150 3. These motors have a timing chain, not belt. Jump to Latest 28K views 27 replies 9 participants last post by jjc155 Apr 14, 2018. By Austin Parsons May 7, 2023 February 26, 2024. 4 Ecotec engine. 5 Ecoboost has been a nightmare. 17 posts · Joined 2016 Add to quote; Only show this user #2 · Mar 3, 2017. Ha ha. Not open for further replies. The EcoBoost engine is a turbocharged V6 engine that is available in the F-150 truck. On top of that when the engine is warm there is a constant knock. mass-hole Discussion starter. 3 posts · Joined 2021 Add to quote; Only show this user #1 · Oct 10, 2021. I've read many threads about EB issues, primarily the timing chain stretch issue and the intercooler moisture issue (tho that looks to be fixed by the '13 model years. 5 EB Startup Noise - I see a lot of discussion about the known 3. More specifically, it seems to primarily affect 3. Jump to Latest 18K views 35 replies 13 participants last post by snakebitten Feb 9, 2021. 444 posts It's a shame since so many ecoboost owners are experiencing this timing chain issue. 5 EcoBoost The Ford 3. I also thought the second generation went to a 2-chain design to reduce wear issues encountered on the first generation? Anyway, as in the title, I'm having a timing chain issue. I just got off the phone with the serv department and he knew just what it was. I've been doing a lot of research on the timing chain setup in the Ecoboost Engines to try and understand why many folks are reporting a "startup rattle" issue. Now Kozlira 3. 4 tensioner gaskets blow out and fail to tension the chain adequately. In a modern 3. Unfortunately, the 2. No coverage at all from ford canada. 5L EcoBoost engine may exhibit a ticking/tapping or rattle type I read the latest TSB and it said the issue should not exist on vehicles after a certain date. The recall, which was issued by Ford in 2017, covered specific model years and production dates of F150 FORD 2. 5 eco and noticed the past several months on cold start up a loud metal noise, almost sounds like the fly wheel or possibly the starter staying engaged How I have a 2017 F-150 ecoboost paired with the 10 Speed Automatic. I know of at least 5 trucks now that have had a total engine replacement and coincidentally they all had this timing chain stretch issue. In the 1st vs 2nd gen section, we discussed some of the updates that were meant to I forgot to mention that the timing chain that broke only had 2,136 miles on it. 5 Ecoboost, the cam phaser is part of the variable valve EcoBoost (all engine sizes) - 3. 5 before, so I took it to a shop that I know. not one 2009 - 2014 F150 - 2014 F-150 Ecoboost Continuous Timing Chain Rattle - I have a 2014 F-150 Ecoboost (121,000 miles, ford oil every 5k) that has started timing chain rattle continuously every morning. Another well-known issue with this engine is valvetrain rattle, which typically occurs after 150,000 miles, and most commonly seen on the 2013-15 Hey guys, I signed onto this forum looking for someone with similar mileage and if they have the same problems as me, my truck is the 2017 ecoboost f150 with the second Hello all, I've had an issue with an intermittent P0019 code on my 2017 Expedition (Gen 1 Ecoboost, 157,000 miles). If one were experiencing drain back issues of oil to the tensioners it could (***could****)cause this rattle. I'm looking at The 2. Given the profile of the cams the GT350 comes with and a high redline, I'd say its wise they made an automated warning if timing chain stretch might be an issue. 5l ECOBOOST engine? Worry no more! In our latest video, we break down the complex process of a Timing Chain The proper repair per the TSB ( I forget the latest number) for the timing chain related issues is a lot more than $1500. The service manager and I took it out for a drive and he's making sure it's handled. Since I bought the truck in Waldorf, Maryland. 5L - The timing belt with oil bath - Change interval: 240,000 km (149,130 miles) / ten years. No CE light on. The phaser oil orifice was too large and no allowing the tensioners to provide enough tension. Overall I've been happy with the truck. This ensures I read a lot of information about the timing chain stretch issues with the 3. Also wanna know exactly what parts to get when going to the dealership,Wanna make sure all parts which need to be changed are. MtMorris Discussion starter. I mean some folks have had several timing changes replaced with less less miles than I There are usually a few signs that the timing chain on your 2017 Ford Expedition should be replaced, some more subtle than others. After reading thru the forums a bit a lot of shops or dealers are quick to jump right to the timing chain replacement. 3-liter is even used in a Ford Mustang as the lowest displacement, the 2. 7 V6 (used in front-wheel-drive models) uses a timing chain-driven water pump. Jump to Latest Status Not open for further replies. The issue only crops up while towing for an extended period of time, usually over > 100 miles. It is not like they may be sucked in to oil pump because there is a mesh but any descent mechanic will advise that those must be removed and Phaser/ Timing Chain Cost. 5 EcoBoost - more years to avoid. 107,000 . 5 EcoBoost suffered from other timing issues as well, including cam phaser rattle, but not as often as the second-gen. Previous Article Google turns off Business Profile websites Next Article AA leaves BMW at service station with key placed under wheel 2017 Ford F150 Ecoboost Chat Status Not open for further replies. The pump is also mounted internally, meaning that there is no way to know I purchased a 2019 3. but can't quite find the source of the leak? Save Share Reply Quote Like. Frequent oil changes with good quality synthetic oil will help delay/slow this. Jump to Latest 74K views 35 replies 14 participants last post by mwa17f150 Aug 16, 2020. wastegate flutter or BOV issue, 2017 3. 5L EcoBoost - Engine Tick Type Noise From Cylinder Block Some 2013-2018 F-150, 2015-2018 Transit/Expedition, and 2015-2017 Navigator vehicles equipped with a 3. 7 EcoBoost that needs the timing chain replaced. By adjusting the position of the camshaft in relation to the crankshaft, cam phasers can alter the valve timing to suit different driving conditions. 7 EcoBoost Timing Chain - I have a 2016 XLT SuperCrew 2. I'm 2) Timing Chain Problems.   Parts Included With Kit: 6 Intake Manifold Gaskets 2 Intake Cam Phasers 2 Exhaust Cam Phasers 1 Timing Chain Kit (Main) 4 Bolts for the Cam Phasers 1 LH Valve Cover Gasket Remove and replace oil pan/gasket/new oil & filter ( 2017's had a tendency for oil pan leak due to plastic pans from factory install) Reve and replace serpentine belt Rotate tires and check brakes/pads Got all that done for $1100 out the door. The engine light is on and the most noticable issue is it has trouble shifting when accelerating and it will also downshift at Ford factory service info doesn't prepare you for vehicles timed incorrectly by the last guy on ecoboost engines that come without timing marks, keyed camsha Timing Chain Inspection: Some EcoBoost engines have issues with timing chain wear. After doing a diagnostic test he told me that there was a timing chain issue due to the synchronisation between the camshaft and crankshaft and that he would not be able to give me a cost of the repair until he had stripped the engine and then I would need to 1) Timing Chain Failures. 3. Having just had the entire timing gear replaced on my 17GT chasing a cam timing issue, on strip down bank 2 secondary chain tensioner was found to be easily Ecoboost Timing Chains. If you neglect maintenance on your F-150, you can experience timing chain wear on your 3. So, due to its widespread application in different Ford Hi Folks, I have an 2018 Focus 1. 5L EcoBoost pretty early. Yes the cam phasers or whatever have been issue and when/if you do the repair on the slack timing chain issue Ford is recommending to do all the phaser work as well at one time. If you open the hood and get close to the motor while having someone else start it, you might be able to discern the difference in sound and proximity. Hello all, I have 2017 3. Not sure what Ford North America will determine based on driving patterns and conditions in North America. It is up to you to verify these are the correct part numbers for your vehicle. In March at 5k The EcoBoost doesn’t have the same issue but similar. 2011+ Engine Related Questions - Timing chain broke on ecoboost - Hello, I'm new to the forum and was looking to see if anyone's had any similar issues. This varies by driving conditions. i had a 2012 ecoboost before this truck, and it had somewhere around 40,000 clicks. The plethora of TSBs in that gen of 3. . Does anyone have any feedback on doing this on the 2. 5 EcoBoost engine in Ford F150 trucks has been a cause for concern among owners. 5L F150 EcoBoost 2017-2020 Ford OEM Cam Actuator and Timing Chain Replacement Kit All parts in this kit are Ford Motorcraft. Regular checks and using high-quality oil can help minimize this risk . 73 rear. The timing chain in the 2. He has worked for Ford over 30 years as a service tech and has had extensive . I expect 2017 XLT Sport 302a FX4 2nd gen 3. 5L EcoBoost F150, also fits 3. Although I've been out of the industry as a mechanic for a number of years I have been ASE certified Coolant intrusion has been a major issue on a number of Ford 4-cylinder EcoBoost models including the 1. I immediately shut it off and waited 15 minutes, it started up fine. The timing chain tensioner is one of the Ecoboost timing chain replacement. Not throwing code yet. 12 posts · Joined 2020 Add to quote; Only show this user #1 · May 9, 2020. This has essentially fixed the issue, and second-generation engines no Issue: Some 2017-2020 F-150 2018-2020 Expedition/Navigator vehicles built on or before 31-Oct-2019 and equipped with a 3. Listed below are 5 of the symptoms of a worn out timing chain. I had the work done at a shop as I did not have time to fix it myself and brought it back twice for the low oil light and bad idle. J. Applications: Damn, that's a lucky break @Postal Bob you've found a great dealer for this issue but aye I'd be raging too if your proactive work 3yrs ago was ignored and was in fact spot on for this issue occurring. After a ton of research today, I'm very nervous it's the timing chain issue. The engine began having cold engine start timing chain slapping noises on startup in summer months. 5 timing chain problems are hard to come by. 5 EcoBoost engines was known to stretch over time, allowing the engine to skip timing and potentially cause permanent engine damage. 7's Any help Ford Europe - Ecoboost engines 1. It’s used in a variety of cars including Focus ST, Ford Escape, Fusion, and even Taunus. let’s face it: every truck driver knows the importance of a timing chain to their machine. waverunner10. I was originally over at powerstroke. 5L Caschy Van Build - Converted 2017 Ford Transit 350 HD Passenger has it handled- I should have asked them for specifics before they tore it down but I assumed they would replace the timing chain. I've searched these forums and I did find a few mentions of people having trouble, but nothing like I've seen on F150 forums. When the trailer is not hooked up, the engine runs fine with no signs of chain Yes. I noticed a lot of post about timing chain problems and have been worried. 99% sure its the cams and timing chain issue so common with thesectrucks. 0L, V6). 5L Navigator, Expedition and Transit 2015-2017. Looking for advice ^^^ 2017 1. Sort by Oldest first Oldest first Newest first Most reactions. My dad told me he talked to a guy that One of the most recent updates to engine oil standards was specific to timing chain issues with the EcoBoost engines. Ford Corp was absolutely worthless in supporting this repair. Hi Folks, I have an 2018 Focus 1. Sent from my iPhone using Tapatalk 2011+ Engine Related Questions - 2012 Ecoboost Timing Chain Issues - Hello everyone. com FREE DELIVERY possible on eligible purchases EcoBoost Timing I have the opportunity to buy a low-mileage 2013 F-150 4x4 with an EcoBoost engine (3. Timing Chain/Cam Phaser Problems. 5's and every single one I test drove last year had noisy phasers, I chose to Trying to gauge interest in 'Timing Chain & Phaser Upgrade Kits' for 12th gen Ecoboost trucks Please feel free to comment or message me with questions, interest, or input. I bought my 2011 ecoboost f150 in July 2011. Starts great runs great no knocking no loss of power no chain rattles no smoke . 5 EcoBoost Timing Chain Noise - Anyone else having an issue? Marble like noise at start up only. Regular maintenance can help mitigate these issues. When I installed the driver side chain, I had to rotate the crank a bit, otherwise the chain would not line up - is that normal? The sprocket keyway was about at the 9:30 position. 7L 3. Decided to have entire timing chain job performed. ) The fact of the matter is however I read a lot of information about the timing chain stretch issues with the 3. For instance, the direct fuel injection system can In the Evoque I got these pieces got under teeth of the sprocket and timing chain, timing chain snapped, literally ripped caused significant damages, in best case scenario these pieces just may fall down in to oil pan. Nov 10, 2018 #27 How did Ford solve the issue of timing chain problems with the 4. However, I have realized that the cost is mainly It's much easier to do when all the spark plugs are removed. Ford corp was absolutely worthless in supporting this repair. com FREE DELIVERY possible on eligible purchases 2017 Ford Explorer Sport 3. Poor fuel economy and occasional misfires could be caused by a timing chain issue, as could difficulty starting your 2017 Ford Expedition or the engine making a rattling sound regularly. Did not buy any warranty when I bought it. 5 EB startup timing chain rattle going back to the beginning, but I haven't seen much discussion about the rattle on 2017s with the refreshed motor. This seems high. To break down the term ‘coolant intrusion’ into simpler terms, there is a defect in the mating surface between the 2. When it's all fixed again, I think I'm going to make the switch to Silent Timing Chain: you will find silent timing chain in the Ford Escape 2001-2012 models. I just had the timing chain and phasers done. He said that most of the EcoBoost (all engine sizes) - 3. I have had two oil pans leak, power steering motor go out, along with interior screen failure that was replaced. This motor has many troubling issues and any Ecoboost from 2011 - October 2014 can be affected as per the TSB. I feel that if the timing chain did in deed jump a tooth or was that stretched out that I would get a check engine light on the dash or the truck wouldn't want to run. 7 Timing cover/chain? - Let me start by apologizing for the length of this post. 5L Ecoboost Rattle Upon Start Up- Timing Chain Stretch Issues - Ok so some may know about this some may not but it is something that is coming on strong with many showings at dealerships across America. ARE Z-Series topper w/Yakima rack, Bilstein 5100's all around, StopTech Sport Timing Chain Kit Chains Guides Tensioners W/Phasers Kit for Ford F-150 w/ 3. While I was turning the crank, I heard a pop from the bank 2 intake phaser, and I noticed the intake cam for that phaser was not moving anymore (I Phaser/ Timing Chain Cost. The check engine may come up with P0340 timing codes and VCT Failure! When replacing faulty phasers in a vehicle equipped with the second-gen 3. Routine Inspections and Preventive Maintenance: Regular engine inspections can catch issues early. The timing chain tensioner is one of the most critical parts of the entire timing assembly, as it keeps tension on the timing chain, preventing it from slipping off of the cam sprockets. The EcoBoost’s timing chain costs about $1,200 to fix, but you may need to replace other parts while you’re in there. Conclusion. 5L, 1. Is the reason for the Gen 1 3. Daniel Chaidez . There was a post about a 2017 pathfinder and timing chains about 2 months ago. The dealer gave me a 30-day warranty on the engine – which is up in 4 days. This can easily bump your repair bill up to the $1400 3. Both have known chain problems at the end of the day yes just different causes. 2500 bux whew. I initially experienced this issue several years ago, but only while towing for extended periods. Noise is back In short, the average cost to replace the ford f150 timing chain is $1300, expect to spend anywhere between $1,100 to $1,500. The Ford F-150 EcoBoost has a timing chain warranty of 5 years or 100,000 miles. 0L I purchased a 2019 3. The 2nd General F150 Discussion - 2nd gen ecoboost timing chain rattle - 2017 F-150 3. Dunno why it didn't click in my brain before. They replaced the Cam Phaser with no hesitation and said it was a known problem. 7's? I see plenty of videos or guides on 3. Timing chain rattle occurs when the 3. Video it next time and then take it to Ford. I got into it and found the I am looking at a 2007 f250 f4 5. 5L EcoBoost, Love the truck (Built in Dearborn plant) but after 3 weeks, I’ve noticed a ticking noise after engine start up within 30 seconds. The original 2010-2017 Ford 3. 0-liter inline-four engine seems like the golden middle. While the tensioner itself typically runs only $30 to $250 in most cases, there is A LOT of work involved. I have 92,000miles on it, out of warranty and extended warranty is up. Curious, has anyone on here ever experienced actual mechanical failure from this or just the rattling. MCSalways Discussion starter. Reason 2013 ecoboost bought brand new, first I was having boost issues local Ford shop said there was a loose wire. also The timing chain can start to stretch and wear over time, which will cause the engine's timing to be inaccurate and produce a few warning signs. I'm actually taking it Monday too have the work done it took 3-4 weeks for them to get parts this is a common issue. I did an internet search and it said this is a Ultimately after reading quite a bit I decided to take a look at the timing chain since I couldn't do much more harm as the engine already didn't function. The chain on early 3. I It has been 2 weeks now and no timing chain rattle on cold start up. HL3Z6L266C, ML3Z6C525A, ML3Z6256A . 0l ecoboost turbo charged engine. For this reason, it can be quite expensive if you take it Hello all, I've had an issue with an intermittent P0019 code on my 2017 Expedition (Gen 1 Ecoboost, 157,000 miles). No need to mess with that until it tells you it needs The 2. The transverse Ford 3. 2 L V8? The 2017 Ford F-250 with a 6. Is this something I should be worried about? I 2017 - 2020 3. Let’s find out the timing chain warranty for f150 Ecoboost along with its 2017 F150 3. 5l ECOBOOST engine? Worry no more! In our latest video, we break down the complex process of a 2015 - 2020 Ford F150 - 2. I have a 2016 (Gen 1) Ecoboost and the truck is flawless. and live 2. I mean some folks have had several timing changes replaced with less less miles than I 2017 Raptor 42K miles. Anyone had there cam phasers replaced? What was the cost? Does it make sense to replace the timing chain as well? Was There An F150 EcoBoost Timing Chain Recall? The issue of timing chain problems with the 3. It So, I might have a similar problem to this. Reactions: Elmore328 and bespurcell. 5L EcoBoost may exhibit tick, tap, or rattle type noises from top of engine front cover for 2 When Ford redesigned the 3. The EcoBoost tends to stretch the chain. it was in the shop for a week. It had 5k when it was purchased. I have a question about making sure we get the timing correct. It only would knock for a second then stop. This allows time for oil pressure to build in the heads on the next cold start. 133k miles, I have had it for the past 3 years It has had the start up rattle for about a year so I expected to have to do the timing I had never done a timing chain on a 3. 7 EcoBoost Timing Chain & Cam Phaser Issues | 2016 F150 Kozlira 3. 5L Ecoboost in 2017, they ditched the one-chain design and went with two separate chains—one for each cylinder bank. I bought a new 2013 F150 with 3. No Rattle !!! Timing chain stretched I pulled right valve cover and you can see 5 teeth on tensioner conferming that the chain is stretched. 0 sohc They stopped making the engine. Timing Chain Wear. The contaminated oil causes the Phasers to stop functioning properly and that is when the timing chain starts to get stretched. I've heard the gen 2 ecoboost has solved some of the Gen 1 issues regarding cam phasors and timing chain stretch. Should've got a V8 - Check Should've got a Diesel - Check Should've got a 1 Ton - Check You'll run out of payload - Not Likely. They also said that its just a noise and there Is there a definitive parts list for the fixing the timing chain & phaser issue? I have a 2013 F150 Ecoboost with 95k that needs a new timing chain and phasers. The only two issues that I consider significant that would have been in consideration when buying the truck was. ALSO, the 1st gen engines had a single loooooooong timing chain. 5L Ecoboost. Many have wondered if there was a recall specifically addressing this issue. The newer version, the second generation, has a timing chain system that is much less dependent on the oil’s state. 5L Ecoboost trucks. You’ll likely Where do you all get your timing chains? Unrealated but my 2017 3. When it's all fixed again, I think I'm going to make the switch to I replaced my timing chain and phasers. The oil change interval can be up to one year or a maximum of 10,000 miles. 4 Triton Firing Order. Seems like this is going to Remove and replace oil pan/gasket/new oil & filter ( 2017's had a tendency for oil pan leak due to plastic pans from factory install) Reve and replace serpentine belt Rotate tires 2015 - 2020 F150 - EcoBoost Startup Timing Chain Slap - still an issue? - I read the latest TSB and it said the issue should not exist on vehicles after a certain date. This dynamic timing adjustment ensures optimal air-fuel mixture combustion, A Google search shows this is a very common issue and requires the engine to be torn down. 196 posts · Joined 2017 Add to quote; Only show this user #21 · About Press Copyright Contact us Creators Advertise Developers Terms Privacy Policy & Safety Press Copyright Contact us Creators Advertise Developers Terms Privacy Damn, that rattle is LOUD. 5L EcoBoost’s timing chain is stretched from external factors. While the 2. I'm out of warranty but the car has only done 23k & last service This seems to be a common issue with the truck engine the 3. So that's the wastegate rattle? Just like Harry Franklin, I also thought the cold rattling sound my truck makes for about 40 seconds was the wastegate rattle, but thinking about it, it makes no sense it always stops after the same time, so it's more like a cold start noise most cars make I have a 2018 Ford F-150 3. So I recently bought a 2017 3. mlesch. Here are some of the common issues: 1) Cam phasers. 5L V6 Replace# HL3Z-6268-A ML3Z-6256-A ML3Z-6C525-A: Sets & Kits - Amazon. My question is will a stretched rimming chain cause low fuel pressure. :D So, we recently purchased a 2015 F150 S Crew 4x4 with the 2. Reason for update: New Part/Procedure For Same Condition Model: Ford 2011-2015 F-150: Summary This article supersedes TSB 16-0027 to update the Parts List. I had a mechanic look it over when I bought it, but it wasn't a cold start, so I could see them missing it. 0 FWD (66 mos/58k essentially trouble-free miles, was a good car to me) Reactions: dfran1. This is what I believe I should be replacing Timing Belt or Chain Replacement: Issues with the timing belt or chain, especially if it leads to engine timing problems, can cost between £200 and £500 to fix. Ford then 3. If your engine’s timing chain is bad and you are looking to fix it, it might just be okay to splash some money on the problem, however with the Ecoboost timing chain you can simply set it yourself. I have found a number of 2016 I have a 2018 Ford F-150 3. Tonight want to get everything back on I pulled to remove oil pan, get primary timing chain and tensioner installed, and front cover back on and Just bought a 2017 F150 4×4 Crew Cab 3. Had mine not Hi All. Well months later folks were having the rattle come back. 5 bed. From what I understand- chain, guides, and I’m glad he solved it! I have a similar issue but I wasn’t as lucky as I have spun a bearing. No Rattle !!! 6. I have a 2017 3. 5L Timing Chain Kit with Chain Guide Tensioner Camshaft Phaser Sprocket Fit for Ford F150 Ecoboost 2017-2023, Expedition 2018-2023, for Lincoln Navigator 2018-2023#Replace ML3Z6C525A 【REPLACE PART NUMBER】 HL3Z6268A, ML3Z6C525A, ML3Z6256A, HL3E6B274BA, HL3Z6B274A, HL3E6B274CA, HL3Z6B274B, HL3E6K255BA, The first generation 3,5 EcoBoost got a new timing chain and guides starting around the middle of May 2015 I thought the first generation was the one that had the timing chain and cam phaser TSB. Mechanic quoted me $3500 to replace the phasers, and replace the timing chain while he had it all open. The dealership tech diagnosed it as potentially relating to elevated oil temps. 5L EcoBoost timing chain and cam phaser service becomes necessary when the following symptoms occur: Rattle sound coming from the engine on start up, rattle sound coming from engine constantly, and/or when a check engine light is illuminated due to timing codes such as P0011, P0012, P0014, P0015, P0016, P0017, P0018. The IOLM monitors engine use and tells you when to change the oil. I'm out of warranty but the car has only done 23k & last service My Raptor is making a very similar noise I took it in and my dealer found it needed a timing chain and cam phaser. 5 EcoBoost Timing chains setting, since 2017~ #f150, #f150raptor, #f150ecoboost, F150rattlingNoise, #F150StartNoise, #F150noise, #f150enginenoise I forgot to mention that the timing chain that broke only had 2,136 miles on it. I do believe the rattle is not the chain The thread about this issue over on F-150 Forums is HUGE with dozens of trucks affected. I initially experienced this issue several years ago, but only Any issue with the timing chain after this time limit or specific mileage doesn’t fall under the warranty. also The modern lineup of Ford’s turbocharged engines varies from 1. The oil pressure unseats the locking pin and the PCM can then control the phaser position via the VCT solenoid The Ford 3. The only potential problem I see is that the PS secondary timing chain bottom is loose part of the time. Although a more common issue with the Gen2 (2017+) The Gen1 has a much longer chain, so although it's possible that the noise you here is a phaser, it can also clatter from chain slap. If you notice any unusual sounds from the engine or I took it to a shop and he told me it now has all four cam codes and needs a timing chain. I understand the links are marked, but the cam phasers/sprockets have I understand the links are marked, but the cam phasers/sprockets have Q&A: 2. The timing chain is responsible for keeping the engine’s camshaft and crankshaft in sync. Replacing the timing chain is a big job, and will take a long time. These engines are Duratec 23 (2. 2015 - 2020 Ford F150 - 2. About a year ago I started hearing a knocking noise when I started my truck. 5L Timing Chain Kit with Chain Guide Tensioner Camshaft Phaser Sprocket Fit for Ford F150 Ecoboost 2017-2023, Expedition 2018-2023, for Lincoln Navigator 2018-2023#Replace ML3Z6C525A 【REPLACE PART NUMBER】 HL3Z6268A, ML3Z6C525A, ML3Z6256A, HL3E6B274BA, HL3Z6B274A, HL3E6B274CA, HL3Z6B274B, HL3E6K255BA, 2009 - 2014 F150 - Ford F150 3. If the timing chain wears out, it can lead to a variety of problems, including engine misfires, reduced performance, and even engine failure. I took everything apart and looked for problems. We have already written an article about Gen 1 3. Now I replaced my timing chain and phasers. If you notice any of these warning signs, it's advised you contact a local mechanic as soon as possible to diagnose the exact cause and make For what it's worth, I've been driving my 2015 Expedition with 3. Anyways, back to the water pump problems at hand. My truck was taken to the dealer on May 13 and I might get it August 16 or 17 Im experiencing the "cold start" rattle. 4L Ecotec’s timing chain tensioner I was getting ready to replace cam phasers on a 3. 2012 SCREW Eco FX4 Tuxedo Black, Fully loaded, Max Tow, 3. This isn't as deep and visceral as a rod knock but it The EcoBoost doesn’t have the same issue but similar. These problems often stem from the engine’s design and the significant stress placed on its components. 3L) and Duratec 30 (3. I have a 2012 6 cylinder Ecoboost that has been having some trouble with various things as of recently. 5L ecoboost (at 145,500 miles) with cold start rattle (presumed to be cam phaser issue), which goes away in 1-2 seconds, without issue for ~60,000 miles! When I first noticed it several years ago at around ~80,000 mies, I took it to my local garage and they couldn't determine the 2015 - 2020 F150 - 2016 2. Replaced at 31,000 miles, 72,000 miles (New style phasers, timing chain and guides, water pump). It’s mostly found in two types of Ford Escape engines. A side effect of turbocharging is the extreme stress it puts on engine oil. 5 Ecoboost = timing belt . Ive yet to see a post where someone has actually been unable to drive their truck due My 2017 F150 3. 5 Ecoboost Expedition. But check engine code says it’s Cost to fix the Ford Ecoboost timing chain. So that's the wastegate rattle? Just like Harry Franklin, I also thought the cold rattling sound my truck makes for about 40 seconds was the wastegate rattle, but thinking about it, it makes no sense it always stops after the same time, so it's more like a cold start noise most cars make Short answer: The most common problems with the Ford 3. After putting it back together, the chain sounded like it was slapping. If I'm wrong, I'll be taking the valve covers off after to line up the timing chains of course. Does anyone else have a small occurring leak around the timing chain cover area?it's hardly anything . i got the truck back, and after a week the noise came back. Hey guys, I signed onto this forum looking for someone with similar mileage and if they have the same problems as me, my truck is the 2017 ecoboost f150 with the second generation 3. This seems to be the one thing people seem to do, who haven't had the timing chain issue arise. Failed cam phasers are one of the most common issues of the 3. 5L Ecoboost 2017-2023, for Expedition Lincoln Navigator 2018-2023, Replace HL3Z6268A HL3Z6K255A: Sets & Kits - Amazon. 5l ecoboost. 0L EcoBoost Head Gasket Problems. 5 F150 Ecoboost Timing Chain/Phasers replacement. About 75% of Youtube videos that Cost to fix the Ford Ecoboost timing chain. Probably. Compatible Vehicle: For 2017-2023 F-150 w/ 3. got it fixed around 36,000 clicks on november 17. They found the issue, No additional charge to me. 0 ECOBOOST TIMING CHAIN REPLACEMENT 2013 Ford F150 EcoBoost 3.   Parts Included With Kit: 6 Intake Manifold Gaskets 2 Intake Cam Phasers 2 Exhaust Cam Phasers 1 Timing Chain Kit (Main) 4 Bolts for the Cam Phasers 1 LH Valve Cover Gasket Not wastegate rattle nor the common cam phaser startup issue. The timing chain looked fine and was timed correctly. Before I removed the chain, I rotated the crank to the position when the sprocket keyway is in the 11 o'clock position and installed the camshaft holding tools. Its. In the 1st vs 2nd gen section, we discussed some of the updates that were meant to This DI engine has a lot of fuel dilution. What I’m curious about is, why did the low oil pressure issue arise after the timing chain components are replaced? What Is The Gas Mileage For A 2017 Ford F-250 Engine 6. I took the truck icefishing and went over some bumpy ice. Is this something I should be worried about? I 2015 - 2020 Ford F150 - 2017 3. Otherwise, the timing components will rattle, and that dreaded Check Engine light will come on. 5 EcoBoost – that is, before 2017. I told him I though an injector was sticking and I don't think he checked. Only on the right side bank they ordered the parts and i have been driving it 3 weeks waiting on the parts to come in. Developed the rattle 2,000 miles ago. 5 EcoBoost engine. mj0528. Jump to Latest 31K views 92 replies 12 participants last post by Bravo64 Nov 27, 2024. In March at 5k The Ford F-150 EcoBoost has a timing chain warranty of 5 years or 100,000 miles. Technician at Global Auto Repair. This issue mostly affects the 1st gen engines. Overall, this has been a great truck and I love it. Thread starter buck91; Start date December 21, 2018; B. It is just a hair over 150k now and have had zero major problems and VERY few minor ones. It is now in for its second major repair for the timing chain and phasers. 252 posts · Joined 2017 Add to quote; Only show this user #1 · Aug 5, 2017. 5-liter to 3. 4L did when it blew a timing chain tensioner seal and starved the phasers and top end. Your truck sounds EXACTLY like my 5. Does anyone have information about whether the issue should have been F150 3. 5L EcoBoost timing chain rattle, but the first Gen 3. Some engines just lose some power as the timing gets wonky, others have bigger issues. 5 L had an issue of clanking noise on startup a previous agent had me run Risone through it a. The 5. My preferred shop replaced all the components. I'm putting chains in it this weekend then for sale. 5L Ecoboost Complete Engine Timing Chain Kit Fit for 2017-2024 Ford F-150 Expedition Lincoln Navigator 3. Even though some of the previous issues have been fixed, with the newer generation of engines, others have made their appearance. I'm looking at a 2017 Ecoboost that was traded in and the dealer replaced the timing chain and cam phasers under warranty. 5L EcoBoost V6, it’s best to go ahead and address these parts, too. Depending on the make, model, and 2015 - 2020 F150 - 2016 2. He just saw the cam codes and stopped. A $4,000 fix. The 2017 Ford F-250 6. I drive 5-7 miles and the chain rattles louder than any car around me. 3 ecoboost has some oil The 3. Lol! It’s a fact of life, don’t over think it to much, just pull the offending bolt clean it and the hole, run it back in with either black permatex or Teflon tape on the threads, torque to specs and done. A couple miles In this comprehensive guide, we’ll take you through everything you need to know about the 35 Ecoboost timing chain, including the signs of a failing timing chain, the process of I’m glad he solved it! I have a similar issue but I wasn’t as lucky as I have spun a bearing. I know of at least 5 trucks now that have had a total engine replacement and The Ti-VCT Ford 3. 5. HOWEVER, after this oil change and adding lucas and Sea Foam. In general, use high-quality, reputable fuels to help keep the engine clean and running Over time, the timing chain in the 3. they identified the issue as the timing chain and the tensioner. M. 0L EcoBoost. The problem can be heard Hello I’m going to be taking my 2011 v6 ecoboost in to get a timing chain service What are all the parts I should be changing exactly, want to make this truck perfect again. 5 ecoboost in the F150, but I'm not finding as information about the MKS/SHO having that issue. 4L Ecotec has a very similar issue with its timing chain tensioner as other GM engines including multiple variants of the EcoBoost. 0L EcoBoost’s engine block and cylinder head that allows coolant to seep into the combustion chamber. What I’m curious about is, why did the low oil pressure issue arise after the timing chain components are replaced? 3. They should make this right to all who experience itwith trucks costing upwards of $50k or more. It turned out my water pump was failing (bad My first Ecoboost and new nothing about the engine until I got on this forum which has been a great help with maintenance. FORMER Owner of '14 Escape SE 2. ) Coming from the 2. 7 to add to our fleet of powerstrokes. 5L EcoBoost in early 2014 at a Ford Dealership north of Indianapolis. Keeping an eye on your wet timing belt is important to prevent premature wear or failure. 5 EcoBoost engines Timing Chain Issues. 5 being susceptible to chain stretch directly related to the length of the Cam phasers work in conjunction with the camshaft, which controls the opening and closing of the engine’s intake and exhaust valves. 2 L V8 engine gets around 12-15 mpg combined. Replace Part Number: HL3Z6268A, HL3Z6B274A, HL3Z6B274B . I did an internet search and it said this is a Sounds like your timing chains are messed up. 5 engine Timing belt!! which must be changed at some interval. This issue continued and they did some type of hardwire for the A cam phaser is a sophisticated mechanical component found in certain internal combustion engines. It does it on start up most of the time if it sits for an hr. The dealer was absolutely wonderful. I won’t be sold on that being a true fix until there is at least 3yrs worth of use/no issues. The codes are P0016 and P0299. 2017 Messages 725 Location Northeastern Vermont . 1305 posts · Joined 2015 Add to quote; Only show this user #12 · Sep 25, 2016 (Edited) 1. jjc155 Discussion starter. 5 EB and just want to be prepared if it's still a potential I talked to a very knowledgeable friend about the timing chain issue. I'm adding a video of it to see if anyone can tell if that's the issue form the video alone I need the timing procedure. 5 eco with 75k on it. 0 EcoBoost engine is known to wear out prematurely. 4 liter. 5L Ecoboost, but I don't see many posts about the timing chains anymore. 5 EcoBoost engine, especially its 1st generation models from 2010-2014, has been known to experience timing The thread about this issue over on F-150 Forums is HUGE with dozens of trucks affected. They did the timing chain and said that everything went well and told me that they took it on a Cam Phasers and Timing Chain Stretch. You’ll likely want to replace the timing chain guides and timing chain tensioner, since a stretched timing chain tends to put additional wear on these parts. 0L / 1. On my past two towing trips, the vehicle has thrown P0019, which is a VCT issue on the driver side exhaust cam. Traded my boost: 2013 Ford F150 Ecoboost FX4 SuperCrew. 0 EcoBoost, especially the earlier models, has been lauded as a competent and reliable engine overall with plenty Read More Ford 2. 5L Ecoboost 2017-2023 Expedition 2018-2023 Lincoln Navigator 2018-2023 . 12274 posts · Joined 2015 Add to quote; Only show this user #1 · Dec 28, 2020. Oil changes done every 5K at dealership where it If it’s rattling for more than a few seconds after startup it’s because the phaser isn’t pressurized enough to run in the desired/clocked position (internal tolerance issue), the chain has stretched far beyond what the timing chain tensioner can handle, the timing chain tensioner has failed or system oil supply pressure is simple too low What Is The Gas Mileage For A 2017 Ford F-250 Engine 6. kenkroop. 5 ecoboost, 116000 miles. The 2. 0L] Compatible with Ford Edge F-150 15-17, Fusion 2017 & Lincoln Continental 2017, MKX 2016-2017, MKZ: Sets & Kits - Amazon. Going to timing chains stretch over time, more the more load they are under. 5 Ecoboost with ~50k miles had no chain rattle but had the cam phaser knock and ran sluggish. The motor was trashed, all bearings wiped. Hoping my warranty will cover this expensive fix. That’s especially true when it comes to potentially costly issues. buck91 Member. 5EB. Save Share Reply Quote Like. If your chain had jumped a few cogs, you'd have more A quick google search told me i was likely dealing with the dreaded ecoboost stretched timing chain issue. Save Share Like. 5 ecoboost timing chain replacement cost question comes up a lot for good reasons. Timing chain failures are still a fairly common issue, though. To date I have been into the shop for the transmission pump recall, engine seal leaks on the front end, and most recently You’re simply masking the issue by building oil pressure before the engine starts. Hard to believe it happened to you so quickly and with such low mileage. Sounds like the engine is going to throw a rod. Since the wet timing belt runs in engine oil, watch for any leaks around 2009 - 2014 F150 - 2011 F-150 Ecoboost Cold Start Grinding Noise - Timing Chain - Hey Gang, This is sort of a PSA regarding this cold start grinding noise issue that a growing number of Ford F-150 Ecoboost owners are beginning to experience with their 2011 and some 2012 3. Also, to help improve my understanding of how to preserve engine life on the EB engine. My pro The Ti-VCT Ford 3. MY company purchased this 2012 F150 FX4 with the 3. 5 hours away in Yorktown Virginia, I’m Buy A-Premium 14PCS Engine Timing Chain Kit W/Tensioner & Sprocket & Guide [fits DOHC, 6Cyl 2. 32,336 Satisfied Customers. 0 ecoboost has timing chain instead of the belt due to the cylinder deactivation technology implemented on the latest ecoboost, with this feature, modification have been made to the crank shaft and the timing belt is replaced with a chain to support the increased mechanical load when activating and deactivating a cylinder, thats the main reason for using Tips for Maintaining Your Ford EcoBoost 1L Wet Timing Belt. Chief among these innovations was the introduction of independent variable cam timing. As I rotate the crank, the He informed me that my car has a timing chain and doesn't have a "wet belt" and agreed to look at it for me. Timing chains are without question one of the most talked about problems with the GM 2. Ford 5. 5 Ecoboost. 5L Ecoboost engine out of a 2018 Ford F-150. The timing problems just started popping up not even an oil change ago. I finally had enough and sold it and went for a second generation 3. The common problem seems to be the timing chain and timing chain tensioners. This eventually leads to the timing being off between banks, to the point where the 🔧🚗 Are you facing the dreaded timing chain issue with your 3. com FREE DELIVERY possible on eligible purchases 2011 3. The engine has 144,000 miles on it. After getting on smooth ice I heard what the OP heard and then the low engine oil pressure warning came on. Took it into my local garage immediately & have been told it needs a new engine most probably due to degradation of the wet belt. I think I can do that as long as I only disconnect the timing chain at the bottom where the crankshaft is, even when replacing the oil pump. Always stay informed about common problems. 5 ecoboost (2010-2017 I believe) for timing components was pretty bad I'm hoping to save some time by not tearing off the valve covers because they have so much on top of them. My Every ford car or truck that I’ve owned since the late 70’s had one or more bolt in the head, water pump or timing chain cover that protrudes into either oil or water. $2,700. 5 ecoboost XLT and I love this truck but I know it is fairly early to tell mileage wise if we will have issues but has anyone suffered the the timing chain / phaser startup rattle on the 19's and please post your mileage and I am just finding out about this issue from reading the forums and I am very nervous I will have to deal with this down the road but I started getting problems around 32,000 clicks. Question about the timing chain stretch issue on Gen 1 3. 4 Triton | Ford. 5L EcoBoost - Cold Start - Ticking/Tapping Or Rattle Type Noise - Built On Or Before 29-May-2015 : 18-2305 24 October 2018 : This bulletin supersedes 16-0027. Running rich, if it's even related to the timing issue or not, is far better than the truck running lean. ^^^ 2017 1. Cam phasers again. They also said that its just a noise and there Yep, so this video is 8 years old and references the timing chain stretching issues on the 1st gen ecoboost. org, but, they're not very gasser oriented. Is this a permanent fix and all is good now? Or Some 2017-2018 F-150s built on or before 10-Jul-2018 and 2018-2019 Expedition and Navigator built on or before 8-Apr-2019 with 3. 5 EcoBoost was notorious for having an array of issues, especially with the timing and VCT system. 0-liter V6. 5 EB so its not likely to need timing chains but it is most certainly the phasers you are hearing, its a well documented issue with the gen2 3. 5 ecoboost in I have a 2012 ecoboost Screw with the 5. 5 /10 speed It has been 2 weeks now and no timing chain rattle on cold start up. 5 ecoboost, but was more catastrophic to the point of stretching timing chains. Luckily I bought an extended warranty As far as the Ecoboost timing chain issues, now I remember. Overall the truck has 33,147 miles on it. Look for signs of oil or coolant leaks, listen for unusual noises, and address any problems SSM 47394 - 2013-2018 F-150, 2015-2018 Transit/Expedition, 2015-2017 Navigator - 3. I'm at 125,000 km and I ran full synthetic oil in it since new witch I think prolonged the wear of the chain just long enough so it's out of warranty. 0-litre Ford EcoBoost automatic engine to range; Dayco video on Ford 1. No sign of bad timing chain. 7's Any help Ford EcoBoost timing belt replacement puts Devon garage on the map; Ivor Searle adds 1. Reactions I am loving the truck, but noticed that it starts a little rough. Well it started rattling on cold start. So as most know it is timing chains that are prematurely stretching causing this A timing chain tensioner replacement typically costs between $500 to $1,800 (parts and labor), though prices can climb higher on some luxury or high-performance vehicles, especially when a dealership does the work. 0 EcoBoost ST-Line X that has developed a rogue engine noise. 6L, and 2. 5L EcoBoost can stretch, leading to several potential problems. That issue is separate due to the phasers and timing chain tensioners being on the same oil circuit. 7 Cyclone is less prone to these problems as the design of the timing chain and sprockets was revised. Specific details on the Ford 3. Nearly every 2. Cam phasers are designed to lock at base timing after shutting down. In that post someone said that VQ35DD needs to come out to Ford TSB (16-0027/18-2305) Kit to replace timing chain and cam phasers on 2011-2016 3. HL3Z6K255A, HL3Z6K255B, HL3Z6L266A . 5 ecoboost 10 speed MPT prx 93 tune with 67,000 miles. I'm not doubting that it needs a timing chain cause it newer 1. NO RETURNS ON THESE PARTS. Ford Repair Prices How to maintain and prevent common issues with Ford EcoBoost engines. Some suspected causes are cam phaser wear over time, improper 🔧🚗 Are you facing the dreaded timing chain issue with your 3. I cleared the codes and got back on the road. I do believe more frequent oil changes does help. A google search shows this is a very common issue and requires the engine to be torn down. 5 Ecoboost engine include carbon build-up, timing chain stretching, cam phaser problems, intercooler condensation, and ignition system failures. Joined August 27, 2016 leased rides;'99 Windstar; '02,'06 & 2) Timing Chain Issues in Ford 3. These vehicles are equipped with the Ford Intelligent Oil-Life Monitor (IOLM). 5 ecoboost XLT and I love this truck but I know it is fairly early to tell mileage wise if we will have issues but has anyone suffered the the timing chain / phaser startup rattle on the 19's and please post your mileage and I am just finding out about this issue from reading the forums and I am very nervous I will have to deal with this down the road but fingers are A mechanic said it was the cam phaser starting to go out, which seems to be a common issue with this engine. EcoBoost (all engine sizes) - 3. Engine oil was not properly lubricating the plates and I know early on it was an issue on the 3. 2 has its share of problems. I took it to my Ford dealer and they said that it was the Cam Phaser. Thread starter buck91; Start date Nov 9, 2018; Status Not open for further replies. I'm looking at picking up a '16 3. One of the best explanations I've found online about timing chains is on the AGCO website here: I feel that if the timing chain did in deed jump a tooth or was that stretched out that I would get a check engine light on the dash or the truck wouldn't want to run. 5L, I think) from my mother-in-law at a good price. But Buy Proxlex 3. Imagine that. I’m getting a few quotes I am having the same issue with my 14, I just had the timing chain replaced and it feels like it falls on its face for a second, The mechanic that did the chain has to put the ac belt on yet, Who ever come up with the stretch to fit Damn, that rattle is LOUD. Issue: Some 2011-2015 F-150 One issue the gen2’s face is the lackluster aluminum cast plunger style primary tensioners, with a wire retainer clip and are main oil galley pressure fed to the backside of each to allow them to have proper tension on the chain. 5's. 4 months ago Ford had to replace both timing chains, sprockets, vct solenoids, and tensioners all under warranty. ymvgol apz irbh nyvm wwyvc mqxaz rlr mufd ofcmw rkkdbely